Greenhouse CO₂ Supplement

C0₂ supplementation may be worth investigating for a grower that is growing cut flowers, however if the grower is producing vegetables, C0₂ supplementation usually does not increase production enough to offset the added cost of C0₂ supplementation.

Advantages and Disadvantages

The beneficial effects of C0₂ supplementation does not always translate into increased profits in the greenhouse due to a limited response from the plants. The limited response may be due to other limiting factors such as adequate levels of nutrients, water and/or light. C0₂ supplementation will not increase production and therefore profits if all systems in the greenhouse are not already at optimum. The grower must understand that if there is one limiting factor for production then increasing one factor alone will not always increase overall production. Only if the grower is supplying all the other factors and the only limiting factor in the production regime is C0₂, will C0₂ supplementation increase production.

C0₂ can produce larger plants, larger flowers, higher quality plants, flowers, can decrease the time from planting to resale and flowering in some plant species. This decrease in the time to maturity can save considerable heating costs by allowing the grower to start the plants later and shorten the time the greenhouse is heated. It is also important to understand that C0₂ supplementation must be done at the proper time in the growing season depending on the growth habits of the plants, since older plants will not respond as dramatically as younger plants unless the older plants are replacing old growth with new growth. The greenhouse must also be prepared for C0₂ supplementation. If the greenhouse is not properly sealed, excess infiltration of outside air will diminish the effect of adding C0₂. Also a greenhouse that is too well sealed may inhibit the natural air exchanges needed to remove excess C0₂ from the internal greenhouse atmosphere and create toxic levels of C0₂ in the greenhouse.

Methods of Supplementation

There are several methods of C0₂ supplementation in a greenhouse environment. Once the decision has been made that C0₂ supplementation will enhance the productivity of the greenhouse, the grower must understand the advantages and disadvantages of each system. There are a number of low tech approaches the greenhouse grower can use to supplement C0₂.

A cheap method of C0₂ supplementation is the venting of the flue gases from a fossil fuel heating system directly into the greenhouse. This method is however, extremely dangerous to plant health as well as human health as the flue gases can contain poisonous gases as well as the sought after C0₂. Gases such as sulfur dioxide, ethylene, nitrogen oxides and ozone can severely damage green plants. These gases are products of incomplete combustion and are created from burners that are not functioning properly, are not properly supplied with outside air containing oxygen, or are present as contaminants in the fuel source.

Another low-tech method of C0₂ supplementation is composting plant material in the greenhouse. The composting process produces C0₂ but it can produce harmful gases as well as create a reservoir for disease pathogens and insects. The C0₂ generated by these methods is also hard to control and unreliable.

C0₂ generators using hydrocarbon fuels are common C0₂ sources in the greenhouse. These generators are specifically designed to produce C0₂ from the combustion of hydrocarbon fuels. However, if the generator is not properly supplied with adequate amounts of oxygen, the burners are out of adjustment or the fuel source contains high levels of sulfur than harmful contaminates will be produced possibly injuring or killing the greenhouse crop. These generators also produce heat during the process of creating C0₂ and can be used to supplement the heating system during cold periods. The C0₂ generators can also provide too much heat in the greenhouse necessitating venting which will dilute the C0₂ present in the greenhouse and defeat the purpose of the C0₂ generator in the first place. Therefore there are certain advantages and disadvantages to fuel burning C0₂ generators.

The safest method of C0₂ supplementation is the use of compressed C0₂ from cylinders. This C0₂ is pure and free of contaminants and is easily regulated. The possibility of contaminate gas production is eliminated and no supplementary heat is produced. The compressed C0₂ is also more expensive than the previous methods described. Since the cost of C0₂ supplementation must not exceed the benefits, than this method of supplementation must be considered carefully. Pressurized C0₂ may not be available to the grower at a reasonable cost and the grower is then faced with accepting the risks associated with the other methods of C0₂ supplementation. However with a high value crop such as cut flowers the elimination of the risks would far outweigh the extra cost of pressurized C0₂ supplementation.

The crop being grown would be the deciding factor for whether or not to use C0₂ supplementation as a growing tool.

How Does C0₂ affect Plant Growth?

The ambient level of C0₂ in the atmosphere is 340 PPM. At 100 PPM of C0₂ the rate of photosynthesis would be stopped completely. At 150 PPM the plants begin to respire, and photosynthesis is stopped. At this low level the plant will no longer be able to obtain C0₂ from the atmosphere and photosynthesis is restricted. The plant will eventually use all of the C0₂ present, photosynthesis will stop and the plant will die.

The rate of photosynthesis at 350 PPM will be consistent with growing conditions outside of a controlled environment, given that ambient levels of C0₂ in the atmosphere are 340 PPM.

With no other limiting factors such as heat, light and nutrients the plants will photosynthesize at a rate consistent with ambient conditions (i.e. outside of the greenhouse). There may be a slight increase in photosynthetic efficiency due to the higher than ambient C0₂ level, however this increase will probably be insignificant. The level of 1000 PPM C0₂ is very close to the optimum level of C0₂ required, given no other limiting factor, 1200 PPM, to allow a plant to photosynthesis at the maximum rate.

At this level most plants will respond favorably by increasing photosynthesis, however this is dependent on all the other limiting factors being optimum for the plant. Therefore at 1000 PPM the photosynthetic rate should be almost at maximum for most plants. However unlikely, at 10,000 PPM of C0₂ the photosynthetic rate in the plants will be very low due to the closing of the plant stomata and the exclusion of air into the leaf interior.

This level of C0₂ is sufficient to cause toxic effect on the plants and cause damage and eventually death of the plant. Also at this level of C0₂ it would be very hazardous to workers in the greenhouse, as they too would experience C0₂ poisoning. The photosynthetic rate would likely be zero at 10,000 PPM of C0₂ for the above stated reasons.

When To Supplement with C0₂?

The high level of C0₂ at sunrise in a greenhouse is caused by plants respiring and releasing C0₂ into the atmosphere. The respiration process continues in light but at a reduced rate. The plant must be able to produce enough carbohydrates during the light period with photosynthesis to overcome the loss of carbohydrates by respiration throughout the day and night. Since there is no photosynthesis occurring during the dark period, there is a net production of C0₂ from the respiration process.

These high levels of C0₂ are a direct result of the metabolism of photosynthates by respiration. The increase in the level of C0₂ would only occur in a very well sealed greenhouse, as infiltration of outside atmosphere would tend to dilute the increased concentration of C0₂ in the greenhouse. This being the case, the level of O2 (oxygen) in the greenhouse would be lower than atmospheric levels due to its consumption in the respiration process.

C0₂ supplementation is most effective during the period of active growth of the plant, during the light period. C0₂ supplementation should begin in the morning for a short period until desired levels are reached, then the generator should be shut down and the levels of C0₂ allowed to return to ambient before nightfall.

• Greenhouse Energy Calculations
  
• Greenhouse CO₂
  
• Greenhouse Heating and Venting

For further information, contact your GO representative.